Mercury auto news

Report: Feds open investigation into Chevy Express, Ford Freestar rust issues

'Tis the season... for road salt. And with that, comes rust. And what does rust bring? Well, for Ford and General Motors, a National Highway Traffic Safety Administration investigation. According to The Detroit News, NHTSA is looking into potential recalls issues with Chevrolet Express vans and Ford Freestar minivans.

The feds have received five complaints that rust has caused leaking fuel filler pipes on 2003 Express vans. Separately, seven complaints have been filed over excessive rust in the rear wheel wells of 2004 Ford Freestar and Mercury Monterey minivans. The Freestar and Monterey went out of production in 2007. Neither issue has resulted in any crashes or injuries, according to the report.

Ford recalling 126,000 Fusions and Milans over wheel separation concern

Ford has announced a recall of certain Ford Fusion and Mercury Milan vehicles after an investigation by the National Highway Traffic Safety Administration. A total of 128,616 2010 and 2011 models equipped with steel wheels may have been manufactured with wheel studs that could crack and split over time. If that happens, the vehicle may experience a wheel separation.

According to The Detroit News, the company is aware of a total of 30 wheel separation incidents, one of which occurred on the front of the vehicle. Even so, no injuries have been reported as a result of the defect.

The problem apparently stems from the fact that the mounting pads on the vehicles' steel wheels may have been faulty from the factory. In addition, the wheel mounting face on rear disc brakes may not have been installed properly. Ford will inspect the rear disc face and replace them as necessary. In addition, the company will replace all of the vehicle's wheel studs free of charge. Head to the NHTSA website for more information, and click past the jump to view the full recall notice.

Continue reading Ford recalling 126,000 Fusions and Milans over wheel separation concern

eBay Find of the Day: Mercury Marauder two-door convertible

Never underestimate what you'll see on eBay Motors. Take this unique creation, for example. Near as we can tell, it's the same 2002 Mercury Marauder that was modified into a two-door convertible by Ford for the 2002 Chicago Auto Show. According to the seller, this car still boasts its Eaton supercharger bolted to a 4.6-liter V8 engine, and at the time of its debut, the engine was rated at a lofty 335 horsepower. We have a hard time believing that the extra ponies would do much to offset the weight of the additional frame stiffeners and top mechanism on the car, however.

The vehicle is currently offered for sale by a dealer in Lansdale, Pennsylvania, though the listing is mum on how the convertible managed to make its way from Ford's Windy City show stand into the seller's inventory. If you like what you see, the machine can be yours for the princely sum of $75,000 or best offer. Head over to eBay Motors to take a gander at the listing.

eGarage goes live and brings video of custom Mercury Coupe build with it

eGarage has been teasing us for a while now. We've seen some interesting videos so far, but the website itself had remained light on content. No longer. eGarage is up and running, and the videos are good.

One we like in particular follows the build process of a custom 1950 Mercury coupe. The chopped and slammed project is the work of Zane Cullen and his Cotati Speed Shop, located in Santa Rosa, California. Cullen and his team have already put two years of work into this custom cruiser, and it looks like they might have another year ahead of them. Still, if this partly finished Merc looks this good now, we can't wait to see the final product.

Head over to eGarage.com to check out the video showing the progress made so far.

Video: Translogic drives wood-burning Mercury Beaver XR-7

You read the title right, we're talking about the Mercury Beaver XR-7. No, Mercury never officially built a car called the beaver. This is the brainchild of upstate New Yorker Chip Beam, who owns and operates Beaver Energy, LLC. It runs on gases created by wood pellets fermented in a 2,400-degree furnace and fed to a supercharged Ford 4.6-liter V8.

By all accounts, it gets down the road just fine, and has pretty close to full power. The best part is, you can grow the fuel yourself and avoid patronizing big oil, if that's your thing. The only drawback that we can see to the Mercury Beaver XR-7 is the PVC pipe jungle occupying the space that would be the trunk under normal circumstances.

Still, if you're willing to smell like a mountain man and look like a bad Back to the Future knockoff, this ride is right up your alley. Click past the jump to see Translogic's take on this modified Merc.

Continue reading Translogic drives wood-burning Mercury Beaver XR-7

Report: NHTSA investigating Lotus Elise for oil leaks

The National Highway Traffic Safety Administration has received 17 complaints about an errant oil line in the Lotus Elise, and thus, has opened an investigation. The issue concerns the line on the front right cooler, which, having got loose, sprays oil either on the wheel or inside the engine bay.

This investigation pertains to around 4,400 of the little track-day wonders sold in the 2005 and 2006 model years. There have been no injuries, but one car did leave the road and catch on fire. A NHTSA investigation doesn't mean a full recall has been issued, just that your friends in the fed are looking into the matter.

Ford recalls Five Hundred, Mercury Montego sedans over fuel tank woes

Ford has announced through the National Highway Traffic Safety Administration that it is recalling nearly 3,000 examples of its Five Hundred and Mercury Montego (pictured) sedans from the 2007 model year.

The action, which affects 2,945 vehicles, is due to potentially defective welds between the filler neck and the fuel tank, a condition that could result in a fuel leak or the smell of gasoline reaching the occupants. In the worst-case scenario, a leak could cause a fire. Cars with the affected fuel tank problem could see an illuminated dashboard warning light as a result of the evaporative emissions leak being detected.

Ford will inspect and replace the fuel tank at no cost to owners (those who have already had the procedure done at-cost can apply for reimbursement), and the Dearborn automaker will begin notifying Five Hundred and Montego owners beginning August 15. Check out the official NHTSA press release after the jump for further details.

Continue reading Ford recalls Five Hundred, Mercury Montego sedans over fuel tank woes

Kit Cat: Mercury Cougar makes perfect Bugatti Veyron substitute

If you've got a pulse in your wrist and a snapping brain cell in your head, chances are you wouldn't mind parking a Bugatti Veyron in your garage. But for most mere mortals, scrounging up the cash for a physics-bending piece of 16-cylinder glory would require all sorts of unpalatable tasks. Fortunately for those who want to look the part without having to participate in human trafficking, the kit car universe has stepped in to save the day. All you need is a 1999-2002 Mercury Cougar, a boat load of fiberglass and a little patience.

Oh, and $89,000.

Is that cheaper than an actual Veyron? Sure. Is it $73,000 more than we'd pay for this car? Absolutely. For that low price you'll get all the looks of the Bug with a fraction of the actual performance. Buyers can look forward to a blistering 170 horsepower from a 2.5-liter V6 kicking at the front wheels via a four-speed automatic transmission. Don't expect much else.

This particular machine is up for bid via eBay Motors, with four days left on the auction. Act now.

Gallery: Bugatti Veyron kit car

Fitting Retirement: Grand Marquis last Mercury off the line

The signs have come down and retail production ended back in October of 2010. Now, the very last Mercury model has rolled off the assembly line. This last Mercury somewhat fittingly takes the form of a Grand Marquis reporting for fleet duty. It was built at the St. Thomas plant in Ontario, Canada, which is the same facility that continues to produce the Ford Crown Victoria and Lincoln Town Car for fleet and livery duty.

St. Thomas' days are numbered, however, as the factory is slated to close on August 31. When it goes, the Panther platform is likely to follow. So long, and thanks for all the fish memories.

Report: Lincoln getting all of Mercury's ad dollars

Now that the curtain has closed on Mercury, Ford Motor Company will redirect all of its marketing dollars for the oft-overlooked brand to the Blue Oval's luxury outpost, Lincoln. In speaking to Automotive News, the chairman of the Lincoln National Dealer Council, Bob Tasca, Jr., said, "You'll see a lot stronger presence in the advertising of Lincoln in 2011."

Lincoln spokesperson Christian Bokich reminded AN that the automaker is "preparing the way for seven new or significantly refreshed vehicles" that will be launched over the next four years, and the largest ad blitz in 2011 will focus on the refreshed MKX crossover, as well as the MKZ sedan and its hybrid counterpart. Following that, Lincoln has plans to launch a completely overhauled version of its Navigator SUV, an all-new C-segment vehicle and the overhauled 2013 MKZ, which Tasca says will be "strikingly different from its Ford Fusion sibling."